安全管理网

盾构机调试验收方案

  
评论: 更新日期:2019年07月09日

1 编制目的

***市轨道交通*号线***********土建工程,北起点位于*************岗盾构始发井,经*****穿***********至****,通过**********等地,至大学城站结束,采用两台德国海瑞克盾构机施工,为保证盾构机的生产、组装质量,熟悉掌握盾构机的结构、功能、性能参数,在盾构机出厂前和到达工地组装完成之后对S-***、***盾构机的主要性能进行调试验收,调试分为两阶段(车间调试和工地调试),特编制此调试方案以指导盾构机的调试工作。

 

2 调试日程安排

盾构机的现调试、验收安排在**月上旬、下旬,在两台

 

3 调试验收的人员安排

盾构机调试验收在项目经理领导下设盾构机调试验收工作小组,具体负责整个调试验收工作。项目经理全面监管整个工作的各个环节。

具体参加调试验收的人员安排如下:

         项目部总机械师      **

         机电部部长          **

        机械工程师          2名

             电气工程师          2名

             机修工              2名

             电焊工              1名

             电  工              2名

4 调试验收工作安排

在对盾构机的调试验收工作之前,调试验收小组的所有成员集体学

习盾构机的结构组成,掌握本工程所使用盾构机的技术参数,通过对在德国海瑞克工厂和广州重型机械厂监造人员收集掌握资料的学习和监造期间积累掌握盾构机的相关知识,结合其他单位使用盾构机的实际经验,制定出我单位盾构机现场调试、验收的具体条款内容,在设备生产厂家提供的验收项目的基础上予以补充完善,努力做到全面验收盾构机的各项技术性能。盾构机的工地验收项目原则上与出厂验收项目相同,并对工厂不具备验收条件的项目予以重点验收。

4.1 盾构机的性能参数

在盾构机的调试验收之前,验收小组的所有成员集体学习掌握盾构

机的结构和主要技术参数,本工程所采用的盾构机主要技术参数见下表:

名称

技术参数

备注

管片设计

 

 

外径

6,000mm

 

内径

5,400mm

 

管片长度

1,500mm

 

分布

5+1

 

盾体

 

 

前盾体数量

1

 

中盾体数量

1

 

直径

6,250mm

不包括堆焊层

长度(前体和中体)

4,280mm

铆接并带用有密封圈

盾构类型

土压平衡

 

机器最小水平转弯半径

350m

 

最大工作压力

3 bar

 

土压计

5

 

排水泵

1

30m³/h

气闸人行门

1

DN 600

气闸连接法兰

1

 

螺旋输送机连接法兰

1

 

盾尾

 

 

盾尾数量

1

 

型式

铰    接

 

长度

3,300mm

 

密封

3排钢丝刷

 

油脂管数量

8 (2 × 4)

DN 25

注浆口

4

DN 50, 单管

推进油缸

 

 

数量

30

10个 双缸. 10个单缸

分组数量

4

 

油缸顶杆端支承

橡胶

 

最大推进力

34,210kN

@ 300 bar

行程

2,000mm

 

工作压力

325 bar

 

伸出速度

80mm/min

所有油缸

缩回速度

1,600mm/min

一组油缸

铰接油缸

 

 

类型

被动式

 

数量

14

 

油缸尺寸

180/80mm

 

回收缩力

7,340kN

@ 215bar

行程

150mm

 

刀盘

 

 

数量

1

 

型式

装配有滚刀闭式

 

直径

6.280mm

 

旋转方向

左/右

 

超挖刀

1把

50 MM 弧线

刀具

31个单刃滚刀, 4个双刃中心刀,64个刮刀;

 

喷嘴数量

4

 

中心回转体

1

4 根泡沫输送管, 1 根液压输送管

刀盘驱动装置

 

 

数量

1

 

型式

液压回转驱动

 

液压马达数量

8

 

额定转矩

4,500kNm

 

最大脱困扭矩

5,300kNm

 

转速

0 to 6.1rpm

 

功率

945 KW

3 x 315 KW

主轴承型式

固定式

 

主轴承外径

2,600mm

 

主轴承寿命

10 000小时

 

人闸

 

 

数量

1

 

型式

双仓式

 

直径

2,000mm

 

工作压力

3 bar

测试压力 4.5 bar

人数(容纳)

3+2

主室/紧急室

管片安装器

 

 

数量

1

 

型式

中心回转式

 

抓紧系统

机械式

 

自由度

6

 

旋转角度

+/- 200°

比例控制

管片宽度

1,500mm

 

举升油缸行程

1,000mm

比例控制

纵向移动行程

2,000mm

比例控制

控制装置

遥控控制

 

螺旋输送机

 

 

数量

1

 

型式

有轴螺旋式

 

直径

900mm

 

功率

315kW

 

最大扭矩

215kNm

 

转速

0 到 19rpm

无级调速

最大出土量(理论上)

250m³/h

100% 充满时

螺距

600mm

 

出料口门

测试压力 4,5 bar

进料口门

不防水,不能承受压力

皮带输送机

 

 

数量

1

 

驱动

电动

 

带宽

800mm

 

带长

55m

 

输送速度

2.5m/s

 

输送量

450m³/h

 

后配套设施

 

 

管片吊车

2

带机械抓紧装置

液压单元

1

包括过滤器和油箱

冷却系统(泵/油冷器/阀)

1

新鲜水 25°由工地提供

注浆系统

1

 

注浆泵

2

KSP 或 相似型号, 流量 12m³/h

压力测量装置

4

 

砂浆罐

1

容量 4m³ 带搅拌器

泡沫发生装置

1

 

泡沫发生器

1

 

水泵

1

133ltr/min, 7.5kW

泡沫泵

1

300ltr/h, 0.5kW

压缩空气供应

 

 

空压机

1

30kW; 7.5bar; 4.85m³/min

高压空气储存罐

1

1.000 ltr

压力气体调节装置

1

DN65 在盾体内

主驱动装置润滑泵

1

 

盾尾油脂泵

1

 

控制台

1

带空调

主配电柜

1

 

变压器

1

 

水管卷筒架

2

工业水 (新鲜水和用过的水)  软管 DN80

电缆卷筒架

1

用于200m 电缆;本设备不含高压电缆

二次通风设备

1

0.6M风管,消音器SDS6

通风管储存装置

1

1米风管,100米储量

小型起吊装置

1

 

导向系统

1

型号 SLS-T_APD

管片排序系统

1

导向系统

数据获取系统

1

我公司标准配置,中英语

配套系统

 

 

台车数量

5 + 连接桥

在轨道上行进, 开式结构

供电装置

 

 

初级电压

10kV (+5% / -5%)

 

次级电压

400V

 

变压器

2,000kVA

硅树脂型, IP 55

控制电压

24V / 230V

 

照明电压

230V

 

阀工作电压

24V

 

频率

50Hz

 

系统绝缘保护

IP55

 

PLC

S7 (西门子)

主控台

功率配置(摘录)

 

 

刀盘驱动系统

945kW

 

液压系统供给泵

55kW

 

盾构推进系统

55kW

 

管片安装器

45kW

 

辅助设备

22kW

 

油冷却系统

8kW

 

润滑系统

4kW

 

螺旋输送机

315kW

 

泡沫发生装置

11kW

 

砂浆设备

38kW

 

皮带输送机

30kW

 

二次通风

11kW

 

空压机

60kW

 

电源插座及工地用电

75kW

 

合计

1,674kW

 

尺寸

 

 

盾构机总长(大约)

74m

 

盾体和盾尾长 (大约)

7.5m

 

盾构机总重 (大约)

520to.

 

 

4.2 调试验收内容

根据盾构机的结构组成和性能参数、结合监造期间收集整理的相关资

料,在设备生产厂家提供的验收项目之上,制定出我单位盾构机的具体调试验收项目,内容包括盾构机机的结构尺寸验收;各个系统的组成完整情况;盾构机相关部将的功能验收、液压系统、注脂系统、润滑系统、冷却系统、压缩空气系统的密封情况;主要零部件的功能;调试验收过程中由专业人员按项目逐个验收、详细记录。具体验收项目和内容如下表:

Subassembly 01–Shield盾体

01.1.Visual check of general wear protection measures目测检查总体耐磨防护措施

Function

功能

Nominal   额定

Test检测

Workshop车间

Job site    工  地

 

Ok

 

 

01.2.Visual check of shield lubrication points (2”-ball valves)目测检查盾壳润滑点(2英寸球阀)

 

Nominal

Test

Workshop

Job site

 

Ok

 

 

01.3.Functional check thrust cylinder推进油缸的功能检查

Function

Nominal

Test

Workshop

Job site

Stroke [mm]  行程

2.000 mm

 

 

Complete of the quantity and the component

数量及部件完整性

 

 

 

Extension time mode 'advance' [min]

推进模式的伸出时间

25 min

 

 

Retraction time/ cylinder group mode 'ring building' complete stroke [s]

管片贫装模式下油缸组全行程缩回时间

s

 

 

Pressure setting of retraction cylinder

缩回油缸时的压力设定

bar

 

 

Extension time/ cylinders group mode 'ring building' complete stroke [s]

管片拼装模式下油缸组全行程伸出时间

s

 

 

Pressure setting of extending cylinder

伸出油缸时的压力设定 bar

bar

 

 

Retraction time/single cylinder (double cylinder)mode ‘ring building ‘complete stroke[s]管片拼装模式下单、双缸全行程缩回时间

s双缸  #

 

 

Extension time/single cylinder (double cylinder)mode ‘ring building’ complete stroke[s]管片拼装模式下单、双缸全行程伸出时间

s双缸  #

 

 

01.4.Functional check shield articulation cylinders盾壳铰接油缸的功能检测

Function

功能

Nominal

额定

Test  检测

Workshop

车间

Job site

工地

Stroke [mm]     行程

150

 

 

Extension articulation cylinder铰接油缸伸出

Ok

 

 

Retraction articulation cylinders铰接油缸缩回

Ok

 

 

01.5         Visual check of passage for probe drill目测超前钻机通道

 

Function

Nominal

Test

 

 

Workshop

Job site

 

Passage通道

6

 

 

      

01.6        Function check tailskin articulation seal 检测盾尾铰接密封功能

 

Function

Nominal

Test

 

 

Workshop

Job site

 

Articulation seal铰接密封

Ok

Job site

 

Emergency articulation seal紧急铰接密封

Ok

Job site

 

      

  01.7        Check of tailskin检测盾尾

 

Function

功能

Nominal

额定

Test检测

 

 

Workshop

车间

Job site

工地

 

Multi-point measurement tailskin diameter 1

盾尾多点直径测量1

内径 6150

 

 

Multi-point measurement tailskin diameter 2

盾尾多点直径测量2

内径 6150

 

 

Multi-point measurement tailskin diameter 3

盾尾多点直径测量3

内径 6150

 

 

Multi-point measurement tailskin diameter 4

盾尾多点直径测量4

内径 6150

 

 

Number of the seal brush密封刷数量

3排

 

 

The damage of seal brush密封刷损坏情况

Ok

Job site

 

The grease injection passage注脂通道

6x2

 

 

Grease pressure sensors注脂压力传感器

6x2

 

 

Motar injection channel注浆通道

4

 

 

Motar injection pressure sensors注浆压力传感器

4

Job site

 

      

Subassembly02        -Cutterhead刀盘

02.1.Check of concentric running of cutterhead刀盘同心度运转检查

Function

功能

Nominal

额定

Test检测

Workshop

车间

Job site

工地

 

Ok

 

 

02.2.Check of overcut between cutterhead and shield刀盘与盾壳间的超挖检查

Function

Nominal

Test

Workshop

Job site

 

Ok

 

 

02.3.Visual check of wear protection measures目测耐磨措施

Function

Nominal

Test

Workshop

Job site

Face正面

Ok

 

 

Backside背面

Ok

 

 

Circumference周边

Ok

 

 

02.4.Functional check of over cutter超挖刀功能检查

Function

功能

Nominal

Test

Workshop

Job site

Hydraulic  stroke [mm]液压行程

70 mm

 

 

Stroke control行程控制

Ok

 

 

Extension/retraction function of over cutter

超挖刀伸缩功能

Ok

 

 

Pipe installation 管路安装

Ok

 

 

02.5.Cutter head equipment刀盘刀具配备情况检查

Function

功能

Nominal

额定

Test检测

Workshop

车间

Job site

工地

Single disc cutter单刃滚刀

31

 

 

Twin disc cutter双刃滚刀

4

 

 

Bracket边刮刀

8

 

 

Over cutter超挖刀

1

 

 

Buckets right/left顺时针、逆时针可动刮刀

64

 

 

Accessibility for tool exchange刀具的可更换性

Ok

 

 

Injection port position and numbers of foam

泡沫注入孔的位置和数量

8

 

 

Pipe installation管路安装

Ok

 

 

Accessibility for center disc cutter change to cutter bit  and the drawings for  cutting tools set中心滚刀换成齿刀的可能性及刀座图纸

Ok

 

 

Subassembly 03-Cutterhead drive刀盘驱动

03.1.Main bearing  and gear lubrication主轴承及齿轮润滑

Function

Nominal

Test

Workshop

Job site

Control oil flow radial rollers OR 1+4径向滚柱油流控制

Impulslist

 

 

Control oil flow axial rollers OAx1+5轴向滚柱油流控制

Impulslist

 

 

Oil level check of main bearing gear主轴承齿轮油位检查

Ok

 

 

Visual check oil leakage control目测漏油控制

Ok

 

 

Pressure before filter滤清器前压力

Ok

 

 

Pressure after filter滤清器后压力

Ok

 

 

03.2.Functional check grease pump main gear主驱动油脂泵功能检查

Function

Nominal

Test

Workshop

Job site

Level control ‘empty’空油位控制(报警)

Ok

 

 

Automatically filling自动加注

Ok

 

 

Function of the grease pump油脂泵功能

Ok

 

 

Function of the filter grease pump油脂泵过滤功能

Ok

 

 

Level control full满油位控制

Ok

 

 

Outer sealing grease for the main bearing

主轴承外密封脂FA1-6

Ok

 

 

Pressure setting for main bearing outer sealing grease 主轴承外密封脂挤压压力设定

Ok

 

 

Pressure display of main bearing sealing chamber

主轴承密封腔压力显示

Ok

 

 

Inner sealing grease for the main bearing

主轴承内密封脂FI1-4

Ok

 

 

Grease lubrication of screw drive

螺旋输送机驱动油脂润滑F1-F3

Ok

 

 

Lubrication of rotary coupling

旋转接头润滑FD1-10

Ok

 

 

Lubrication for articulation seal-manual

铰接密封润滑—手动

Ok

 

 

Grease lubrication of screw conveyor-manual

螺旋机油脂润滑--F4手动

Ok

 

 

03.3.Functional check of the cutterhead drive刀盘驱动功能检查

Function

Nominal

Test

Workshop

Job site

Boost pressure at the hydraulic drives [bar]

液压驱动压力

>16

 

 

Max. revolutions [min-1]最大转速

6,1

 

 

Rotation left stage 1左转速度1

Ok

 

 

Rotation right stage 1右转速度1

Ok

 

 

Rotation right stage 2右转速度2

Ok

 

 

Rotation left stage 2左转速度2

Ok

 

 

Inching operation maintenance panel left/right

维护控制面板点动操作

Ok

 

 

03.4.Gear box oil减速器齿轮油

Function

Nominal

Test

Workshop

Job site

Oil level of planetary gear box

行星减速机齿轮油油位

Ok

 

 

 

Subassembly04         -Erector管片拼装机

04.1      Function and protection of erector  管片拼装机功能及防护

Function

Nominal

Test

Workshop

Job site

Installation for a possible probe drill complete

一台完整的超前钻机安装的可能性

Ok

 

 

Erector has wire control function

管片拼装机有线控制功能

Ok

 

 

Erector has radio control function

管片拼装及无线控制功能

Ok

 

 

Check oil level of reducer

减速机油位检查

Ok

 

 

Protection function of hose protection chain

管线防护链的防护功能检查

Ok

 

 

04.2Functional check of the erector and its interlocking measures

拼装机功能及其互锁措施的检查

Function

Nominal

Test

Workshop

Job site

Maximum rotation speed [min-1]最大转速

1,6

 

 

Limiting of rotation-angle [°], kind of limit

转动角度限制,限制种类

+/-200, el.

 

 

Stroke of telescope cylinder red [mm]

红色伸缩油缸行程

1200

 

 

Stroke of telescope cylinder blue [mm]

蓝色伸缩油缸行程

1200

 

 

Cycle time telescope extending/retracting [s]

伸出、缩回行程的循环时间

15/15

 

 

Stroke travel [mm]移动行程

2000

 

 

Cycle time travel extending/retracting [s]

(轴向)移动伸出、缩回循环时间

25/20

 

 

Rotation erector head拼装机头旋转

Ok

 

 

Tilt erector head拼装机头倾斜

Ok

 

 

Gripper system for picking up the segments

抓取管片的夹紧系统

Ok

 

 

Securing device against unwanted opening of the gripper system防止加紧系统以外打开的装置

Ok

 

 

Rotation speed adjustment旋转速度调节

Ok

 

 

Extension/retraction speed adjustment of red ccylinder伸缩油缸的速度调节(红)

Ok

 

 

Extension/retraction speed adjustment of blue ccylinder伸缩油缸的速度调节(蓝)

Ok

 

 

Travel speed adjustment forward/backward

前进、后退的速度调节

Ok

 

 

Function of lifting cutters ,tools

起吊刀具、及工具的功能

Ok

 

 

Subassembly05        -Circuits

05.1Functional check ball valves球阀的功能检查

Function

Nominal

Test

Workshop

Job site

Compressed-air drive ball valves 1.1-2.6 tailskin sealing compound

盾尾密封脂挤压空气驱动球阀

Ok

 

 

 

05.2Dewatering system排水系统

Function

Nominal

Test

Workshop

Job site

Water drawing pump shield盾壳内排水泵

Ok

 

 

Maneuverability of pump泵的操作性

Ok

 

 

Line arrangement for dewatering

排水管路布置

Ok

 

 

05.3Filter-/cooling-circuit过滤冷却回路

Function

Nominal

Test

Workshop

Job site

Stop cocks before and after filter/cooler

滤清器前后开关

Ok

 

 

Accessibility high pressure filter

高压滤清器的可操作性

Ok

 

 

Accessibility return line filter

回油滤芯的可接近性

Ok

 

 

Thermometer position (oil temperature)

油温表位置

Ok

 

 

Thermometer position (water temperature)

水温表位置

Ok

 

 

05.4Water cooling circuit冷却水循环回路

Function

Nominal

Test

Workshop

Job site

Function and capability of the double water hose drum进排水管卷筒功能及能力

Ok

 

 

Installation and arrangement for the gantry input and output water hose

拖车进排水管路安装及布置

Ok

 

 

Installation water supply switch of the gantry

拖车供水开关的安装

Ok

 

 

Function filter for the input water return circuit进水回路滤清器过滤功能

Ok

 

 

Temperature and operation pressure display of the input water hose进水管工作压力和温度显示

Ok

 

 

Function heat exchanger热交换器功能

Ok

 

 

Temperature display for input and output water hose outlet of hydraulics cooling

液压系统冷却器进出水口温度显示

Ok

 

 

Operation pressure of the circuit water pump

循环水泵的工作压力

Ok

 

 

Water cooling compressor and temperature display空压机水冷及温度显示

Ok

 

 

Function of the water cooling distribution cabin and temperature display配电柜水冷功能及温度显示

Ok

 

 

Pipe installation for the closed water cooling circuit闭式水冷循环系统管路安装

Ok

 

 

Function drive reducer water cooling and the flow display驱动减速器水冷功能及流量显示

Ok

 

 

Pipe installation for closed cooling circuit

闭式水冷循环系统管路安装

Ok

 

 

05.5Compress air压缩空气

Function

Nominal

Test

Workshop

Job site

Start/stop of the air compressor

空压机启动、停止

Ok

 

 

Pipe installation for the industrial compress air工业压缩空气管路安装

Ok

 

 

Air duct outlet for the spare compressor

备用空压机风管接口

Ok

 

 

Operation pressure of No.1 compressor (Max ,Min)

1号空压机工作压力最高、最低

8bar

 

 

Operation pressure ofNo.2  compressor (Max ,Min)2号空压机工作压力最高、最低

8bar

 

 

Function of condensate drain and filter

油水分离及过滤功能

Ok

 

 

Function of air duct case储风罐功能

Ok

 

 

Brake hose for input and output water hoses

进排水管制动管路

Ok

 

 

Ball valve for compressive air hose on gantry

拖车压缩空气供风开关

Ok

 

 

Air pipe for tailskin grease, main bearing lubrication grease盾尾油脂、主轴承润滑脂供风管路

Ok

 

 

Inflatable hose for articulation emergency seal

铰接紧急密封充气管路

Ok

 

 

Air pipe for foam system泡沫系统供风管路

Ok

 

 

Air supply for waste water pump 污水泵压缩空气供应(油水分离及润滑)

Ok

 

 

Pipe for main bearing and gear box pressure increasing 主轴承及齿轮箱加压供应管路

Ok

 

 

05.6Air pressure regulation土仓压缩空气调节

Function

Nominal

Test

Workshop

Job site

Function filter过滤器功能

Ok

 

 

Function pressure reduce valve减压阀功能

Ok

 

 

Setting service unit 1 positioning drive for pressure chamber [bar]压力仓定位驱动伺服单元1设定bar

4

 

 

Setting service unit 2 positioning drive for pressure chamber [bar]压力仓定位驱动伺服单元2设定bar

4

 

 

Setting pressure reducing valve 1 pressure transducer for pressure chamber[bar]压力仓压力变换器减压阀1压力设定bar

1.4

 

 

Setting pressure reducing valve 2 pressure transducer for pressure chamber[bar]压力仓压力变换器减压阀2压力设定bar

1.4

 

 

Zero point adjustment feed-in-controller 1 pressure chamber压力仓进料控制器1零点调整

Ok

 

 

Zero point adjustment feed-in-controller 2 pressure chamber压力仓进料控制器2零点调整

Ok

 

 

Feed-in –controller 1 pressure chamber completely opened at [bar]压力仓进料控制器1完全开启,在    bar

1.0

 

 

Feed-in –controller 2 pressure chamber completely opened at [bar]压力仓进料控制器2完全开启,在    bar

1.0

 

 

Feed-in –controller 1 pressure chamber completely closed at [bar]压力仓进料控制器1完全闭合,在    bar

0.2

 

 

Feed-in –controller 2 pressure chamber completely closed at [bar]压力仓进料控制器2完全闭合,在    bar

0.2

 

 

Subassembly06        -Gantry

06.1Functional check of segment feeder管片运输机功能检查

Function

Nominal

Test

Workshop

Job site

Extension time feeder [s]运输机伸出时间

25 s

 

 

Retraction time feeder [s]运输机缩回时间

25 s

 

 

Longitudinal displacement [mm]纵向位移

1.760 mm

 

 

Lifting height起升高度

 

 

 

Check of visibility and danger zones for operating staff操作人员视野和危险区域检查

Ok

 

 

Check handing over of the segment from the feeder to the erector从管片运输机到安装机的位移检查

Ok

 

 

06.2Functional check of segment handling crane管片吊机功能检查

Function

Nominal

Test

Workshop

Job site

Possibilities of collision at longitudinal travel纵向位移时碰撞的可能性

None

 

 

Position of stop buffers longitudinal travel

纵向位移停止缓冲器的位置

Ok

 

 

Switching fast-slow at approaching the rail limits or danger zones接近轨道限制或危险区域快-慢开关

Ok

 

 

Cycle time longitudinal travel complete way [s]

全行程纵向移动的时间

73 s

 

 

Protection energy-/ cable rail电缆、电源轨道的防护

Ok

 

 

Time lift/lower 3 m [s]提升、下降3m的时间

50 s

 

 

Lock against unintentional opening of gripper facility防加紧装置以外打开的锁紧

Ok

 

 

Lifting capacity [kN]起吊能力

2x25

 

 

Check of visibility and danger zones for operating personnel

操作人员视野和危险区域的检查

Ok

 

 

Lifting height提升高度

3m

 

 

Synchronization of right /left crane

左右起吊的同步性

Ok

 

 

Rotate segment管片旋转

Ok

 

 

Synchronization of movement of right/left crane

左右吊机移动的同步行

Ok

 

 

06.3Visual check of grease pump 目测检查油脂泵

Function

Nominal

Test

Workshop

Job site

Auto contral自动控制

Ok

 

 

06.4Visual check of jointing compound pump目测检查盾尾油脂泵

Function

Nominal

Test

Workshop

Job site

Manual control手动控制

 

 

 

Auto control自动控制

Ok

 

 

06.5Functional check of grout pump(s)注浆泵功能检查

Function

Nominal

Test

Workshop

Job site

Max. strokes [1/min]最大行程

Ok

 

 

Accessibility and shut-off facilities for cleaning and maintenance清洗保养的易接近程度和关闭设施

Ok

 

 

Function grout injection system注浆系统功能

 

Job site

 

Grout pump rate (Max)最大泵送次数

Ok

 

 

Installation of grout line注浆管路安装

Ok

 

 

Possibility to lay down high pressure hoses

高压软管铺设的可能性

Ok

 

 

Speed control速度控制

Ok

 

 

Manual operation手动操作

Ok

 

 

Automatic operation自动操作

Ok

 

 

06.6Functional check of grout container储浆罐功能检查

Function

Nominal

Test

Workshop

Job site

Mixer operation搅拌器操作

Ok

 

 

Possibility of discharge流出的可能性

Ok

 

 

Gear oil level齿轮油位

Ok

 

 

06.7Functional check of slewing cranes回转吊机功能检查

Function

Nominal

Test

Workshop

Job site

Avoidance of collision with the train in the working area在工作区域内避免与列车相撞

Ok

 

 

06.8Visual check of ventilation目测检查通风

Function

Nominal

Test

Workshop

Job site

Ventilator/ aerator通风机

Ok

 

 

Sound absorber消音器

Ok

 

 

Airduct storage box风管储存筒

Ok

 

 

Storage box handling facility储存筒吊装设备

Ok

 

 

Connection for the airduct and the storage box

风管与储存筒的连接

Ok

 

 

Subassembly 07-Man lock人闸

08.1.Visual check of  man lock 目测人闸功能

Function

Nominal

Test

Workshop

Job site

Access进入通道

Ok

 

 

Seats座椅

Ok

 

 

Check number数量检查

Ok

 

 

Lighting照明

Ok

 

 

Communication function通讯功能

Ok

 

 

08.2.Visual check of locking devices目测检查锁紧装置

Function

Nominal

Test

Workshop

Job site

Compatibility of door locks闸门兼容性

Ok

 

 

Slewing range of doors闸门回转范围

Ok

 

 

08.3.Visual check of seals  目测检查密封

Function

Nominal

Test

Workshop

Job site

Sealing of entrance and exit of small chamber of man lock人仓小腔进口及出口的密封

Ok

 

 

Sealing of entrance and exit of big chamber of man lock人仓大腔进口及出口的密封

Ok

 

 

08.4.Visual check of compressed air installations  目测检查压缩空气装置

Function

Nominal

Test

Workshop

Job site

Safety valve安全阀

Ok

 

 

Pressure reducing valve减压阀

Ok

 

 

Flow valve 流量阀

Ok

 

 

Pressure gauge man lock人仓压力表

Ok

 

 

Pressure recorder 2压力记录仪2个

Ok

 

 

Air pressure gauge in man lock人仓内部气压表

Ok

 

 

Thermometer in man lock人仓内部温度表

Ok

 

 

Clock in man lock人仓内钟表

Ok

 

 

Heater 加热器

Ok

 

 

Telephone电话

Ok

 

 

Lighting照明

Ok

 

 

Pressure gauge man lock

土仓压力表

Ok

 

 

08.5.Pressure increasing man lock人仓加压试验

Function

Nominal

Test

Workshop

Job site

Function pressure increasing man lock

人仓加压功能

Ok

 

 

Increasing pressure to 3 bar 30 min

30min升压至3bar

Ok

 

 

Securing pressure at 3 bar 30 min

30min稳压在3bar

Ok

 

 

Reducing pressure to 3 bar 30 min

30min降压从3bar到0bar

Ok

 

 

Subassembly 10-Screw conveyor螺旋输送机

10.1.Functional check of screw conveyor螺旋输送机的功能检查

Function

Nominal

Test

Workshop

Job site

Maximum revolutions excavate [min-1]开挖最大转速

22

 

 

Maximum revolutions reverse [min-1]反转最大转速

11

 

 

Displacement stroke [mm]位移行程

1.000 mm

 

 

Closing time of screw gate valve No1 [s]

1#螺旋门关闭时间

120 s

 

 

Emergency function screw gate valve No 1

1#螺旋门的紧急功能

Ok

 

 

Minimum pressure after closing via accumulator No 1 [bar]1#门由蓄能器关闭后的最小压力

>100 bar

 

 

Closing time of screw gate valve No 2  [s]

2#螺旋门关闭时间

120 s

 

 

Emergency function screw gate valve No 22#螺旋门的紧急功能

Ok

 

 

Minimum pressure after closing via accumulator No 2  [bar]2#门由蓄能器关闭后的最小压力

>100

 

 

Function mud discharge pump保压泵的功能测试

Ok

 

 

Accessibility and shut-off facilities for cleaning and maintenance清洗和保养的易接近程度和关闭设施

Ok

 

 

Installation input and output hoses进出输送软管的安装

Ok

 

 

Muck unloading outlet position of muck discharge pump输送泵卸渣口位置

Ok

 

 

Max muck pump rate最大泵送次数〔1/min〕

 

 

 

Speed control速度控制

 

 

 

10.2.Functional test pressure bulkhead lock of screw conveyor                                                                      螺旋机压力隔板门的功能测试

Function

Nominal

Test

Workshop

Job site

Front gate open/ close前门开、合

Ok

 

 

Stroke [mm]行程

400 mm

 

 

Locking against unintentional closing内部联锁

Ok

 

 

Subassembly 11-Conveyor belt皮带输送机

11.1.Visual check conveyor belt目测检查皮带输送机

Function

Nominal

Test

Workshop

Job site

Mode convey输送模式

Ok

Job site

 

Mode reverse反转模式

Ok

Job site

 

Smooth start/ braking operation平稳启动/制动操作

Ok

Job site

 

Emergency-stop 紧急停车

Ok

Job site

 

Check of general survey of working area and danger zones for operating personnel

操作人员总体观测工作区和危险区的检查

Ok

Job site

 

Subassembly 24-Foam unit泡沫单元

24.1.Visual check foam unit目测检查泡沫单元

 

Function

Nominal

Test

Workshop

Job site

Flow rate regulation of tenside pump

泡沫剂泵的流量调节

Ok

 

 

Flowmeter of industrial air 1-4

1-4压缩空气流量表

Ok

 

 

Flow regulation valve of industrial air 1-4

1-4压缩空气流量调节阀

Ok

 

 

Flowmeter of water-soap-mixture 1-4

1-4水-泡沫剂混合物流量表

Ok

 

 

Flow regulation valve of water-soap-mixture 1-4

1-4水-泡沫剂混合物流量调节阀

Ok

 

 

Pressure transducer of foam pressure 1-4

泡沫压力传感器

Ok

 

 

Flow rate regulation of water pump

水泵的流量调节

Ok

 

 

Observation foam generation

发泡情况观察

Ok

 

 

24.2.Functional check high pressure polymer pump高压聚合物泵的功能检查

 

Function

Nominal

Test

Workshop

Job site

Function功能

Ok

 

 

Pipe installation管路安装

Ok

 

 

Pumping capacity adjustment泵送能力调节

Ok

 

 

Subassembly 50–Electricity    电气

50.1.Monitoring and cut-offs   检测和关闭

Function

Nominal

Test

Workshop

Job site

Monitoring of boost pressure of main drive/ screw drive pumps

主驱动/螺旋驱动泵驱动压力检测

Ok

 

 

Cut-off at reaching the minimum limit of the boost pressure at main drive/ screw drive pumps

主驱动/螺旋驱动泵补油压力达到最低限位时关闭

Ok

 

 

Monitoring impulses gear oil distributor

驱动齿轮油分配器的监视

Ok

 

 

Cut-off of main drive at reaching the minimum limit of impulses达到最低推进力限位时主驱动关闭

Ok

 

 

Cut-off of main drive at malfunction of gear oil pump齿轮油泵故障时主驱动关闭

Ok

 

 

Monitoring of gear oil level in main gear

主驱动油位检视

Ok

 

 

Cut-off of main drive at reaching the minimum limit of gear oil level

齿轮油达到最低限位时主驱动关闭

Ok

 

 

Warning information ‘gear oil temperature high’“齿轮油温过高”报警信息

Ok

 

 

Cut-off of main drive at XX°C gear oil temperature齿轮油达到      °C时主驱动关闭

Ok

 

 

Monitoring of the hydraulic oil level in tank

油箱液压油位警报

Ok

 

 

Warning information ‘oil-level low’

“低油位”报警信息

Ok

 

 

Cut-off of the pumps at reaching the minimum level in tank油箱内油位达到最低限制时泵关闭

Ok

 

 

Warning information ‘temperature hydraulic oil high’报警信息“液压油温过高”

Ok

 

 

Cut-off of pumps at reaching XX°C hydraulic oil temperature at suction area of oil tank油箱吸油区液压油温达到    °C时泵关闭

Ok

 

 

Cut-off of pumps at reaching XX°C leakage oil temperature at main drive主驱动泄油油温达到    °C时泵关闭

Ok

 

 

Cut-off of pump at reaching XX°C leakage oil temperature at screw conveyor drive螺旋输送机泄油油温达到    °C时泵关闭

Ok

 

 

Monitoring of pull force of tailskin articulation cylinders盾尾铰接油缸牵引力监视

Ok

 

 

Monitoring of stroke of tailskin articulation cylinders盾尾铰接油缸行程监视

Ok

 

 

Monitoring of pull force of gantry pull cylinders拖车牵引油缸牵引力监视

Ok

 

 

Is there any interference to the thrust pump and auxiliary pump caused by erector mode’radio’control安装机无线控制时对推进泵及先导泵有无干涉

 

 

 

Does the foam pump equip idle running protection if no foam agent泡沫泵有无防止无泡沫剂空转功能

 

 

 

50.2.Filter monitoring, fault messages    滤芯监测,故障信息

Function

Nominal

Test

Workshop

Job site

Fault message ‘contamination pilot oil filter’ main drive  主驱动“先导油滤芯污染”故障信息

Ok

 

 

Fault message ‘contamination boost oil filter’ “推进油滤芯污染”故障信息

Ok

 

 

Fault message ‘contamination erector filter’

“拼装机滤芯污染”故障信息

Ok

 

 

Fault message ‘contamination bypass filter’

“旁通滤芯污染”故障信息

Ok

 

 

Fault message ‘contamination return line filter’“回油管路滤芯污染”故障信息

Ok

 

 

Fault message ‘contamination grout pump supply’“注浆泵供油滤芯污染”故障信息

Ok

 

 

Fault message ‘contamination gear oil filter’

“齿轮油滤芯污染”故障信息

Ok

 

 

50.3.Functions of pressure switches, approximate switches, stroke measurement systems压力开关,接近开关,行程测量系统的功能

 

Function

Nominal

Test

Workshop

Job site

approximate switch screw conveyor displaced back  螺旋输送机后移接近开关

Ok

 

 

approximate switch screw conveyor displaced forward  螺旋输送机前移接近开关

Ok

 

 

approximate switch pressure bulkhead lock open

压力隔板仓门打开接近开关

Ok

 

 

approximate switch pressure bulkhead lock closed 压力隔板仓门关闭接近开关

Ok

 

 

approximate switch screw gate valve open

螺旋输送机门打开接近开关:1#,2#

Ok

 

 

approximate switch screw gate valve closed

螺旋输送机门关闭接近开关:1#,2#

Ok

 

 

Stroke measurement system screw gate valve

螺旋输送机门行程测量系统:1#,2#

Ok

 

 

Stroke measurement system of advance cylinder group A  A组推进油缸行程测量系统

     Ok

 

 

Stroke measurement system of advance cylinder group B  B组推进油缸行程测量系统

Ok

 

 

Stroke measurement system of advance cylinder group C C组推进油缸行程测量系统

Ok

 

 

Stroke measurement system of advance cylinder group D D组推进油缸行程测量系统

Ok

 

 

Stroke measuring system of articulation cylinder No.22#铰接油缸行程测量系统

Ok

 

 

Stroke measuring system of articulation cylinder No.5 5#铰接油缸行程测量系统

Ok

 

 

Stroke measuring system of articulation cylinder No.10 10#铰接油缸行程测量系统

Ok

 

 

Stroke measuring system of articulation cylinder No.1313#铰接油缸行程测量系统

Ok

 

 

50.4.Earth pressure sensors土压传感器

Function

Nominal

Test

Workshop

Job site

The number of earth pressure sensors

土压传感器数量

5

 

 

Function of earth pressure sensors

土压传感器功能

    ok

 

 

Earth pressure sensors for screw conveyor

螺旋输送机的土压传感器

    ok

 

 

 

5 调试验收器具

  本次盾构机调试验收所使用的器具如下:

钢卷尺   5m、3m     各1个;

  米  尺   25m           1个;

  秒  表                 2个;

  照相机    光学相机   1台;

  数码照相机       400万像素     1台;

  数码摄像机        sony          1台;

  其他测量仪器如压力表、温度表、电流表、万用表由设备生产厂家提供。

6 质量保证措施

6.1 参加盾构机调试的技术人员、修理人员在调试前经过培训学习,熟悉盾构机的图纸,了解机器的性能,以及调试的技术要求,以确保盾构机调试能顺利进行。

6.2 每调试一个部位,有专人负责进行检查、调试,并有专人进行记录。

6.3 针对调试验收中存在问题的项目收集、整理出相关资料。

6.4 针对调试验收没有达到标准的项目,严格与海瑞克相关技术人员交涉,确保所有项目均到达出厂标准。

6.5 设备验收前对验收人员进行安全教育,保证验收过程中尽量不损坏设备的部件,不发生人身安全事故。

网友评论 more
创想安科网站简介会员服务广告服务业务合作提交需求会员中心在线投稿版权声明友情链接联系我们